Product ID:POLYURETHANE CLEAR GLOSS, 5-8935
MSDS Date:10/21/1992
FSC:8010
NIIN:00N068456
MSDS Number: CBHTZ

WATTYL PAINT CORP

5275 PEACHTREE INDUSTRIAL BLVD
ATLANTA, GA 30341
US

Emergency Phone: 404-455-7000

Info Phone: 404-455-7000

Cage: WATTL

WATTYL PAINT CORP

ATLANTA, GA 30341 US

Telephone: 404-455-7000

Cage: WATTL

2 @ 20C

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 1%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

SILICA

CAS: 7631-89-9

OSHA PEL 20 MPPCF; Z-3

ACGIH TLV: 10 MG/M3 TDUST

TALC (POWDER), CONTAINING NO ASBESTOS FIBERS

CAS: 14807-96-6

RTECS: WW2710000

OSHA PEL 20 MPPCF

ACGIH TLV: 2 MG/M3 RDUST

CALCIUM CARBONATE (MARBLE) (LIMESTONE)

CAS: 1317-65-3

RTECS: EV9580000

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

TITANIUM OXIDE; (TITANIUM DIOXIDE)

CAS: 13463-67-7

RTECS: XR2275000

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

SECTION SHOULD BE CAREFULLY OBSERVED & RESPS SHOULD

RTECS: 9999999ZZ

SUCH A WAY AS TO PRODUCE DUST.

RTECS: 9999999ZZ

WHERE ANY TLV LISTED IN INGRED SECTION MAY BE

RTECS: 9999999ZZ

EXPLOSION SECTIONS.

RTECS: 9999999ZZ

FULL LENGTH FACESHIELD .

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHALATION:ANESTHETIC.
IRRITATION OF THE RESPIRATORY TRACT, OR ACUTE NERVOUS SYSTEM
DEPRESSION CHARACTERIZED BY THE FOLLOWING PROGRESSIVE
STEPS:HEADACHE, DIZZINESS, STAGGERING GAIT, CONFUSION, U
NCONSCIOUSNESS OR COMA. SKIN OR EYE:PRIMARY IRRITATION. CHRONIC:MAY
CAUSE RESPIRATORY AND/OR SKIN (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:SENSITIZATION. PERMANENT CENTRAL
NERVOUS SYSTEM CHANGES DUE TO SOLVENT OVEREXPOSURE HAVE BEEN
REPORTED.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL:REMOVE FROM EXPOS. RESTORE BRTHG. TREAT
SYMPTOMATICALLY. CONSULT PHYS. EYES:FLUSH IMMED W/LG AMTS OF WATER
FOR @ LEAST 15 MINS. TAKE TO PHYS FOR MED TREATMENT. SKIN:WASH
AFFECTED AREAS W/SOAP & WATER. REMOVE DRENCHED CLTHG. CONSULT PHYS
IF IRRIT PERSISTS. INGEST:DRINK 1-2 GLASSES OF WATER TO DILUTE. DO
NOT INDUCE VOMIT. CONSULT PHYS OR POIS CTL CTR AT ONCE. TREAT
SYMPTOMATICALLY.

Flash Point:100F,38C
Lower Limits:1.0%
Extinguishing Media:USE NATIONAL FIRE PROT ASSOC (NFPA) CLASS B
EXTINGUISHER/EXTINGUISHING AGENT DESIGNED TO EXTINGUISH FLAM LIQUID
FIRES.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPK & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN
EXPOS TO EXTREME HEAT. APPLIC TO HOT SURF REQS (SUPDAT)

Spill Release Procedures:REMOVE ALL SOURCES OF IGNIT (FLAME, HOT SURF,
& ELEC, STATIC OR FRICTIONAL SPKS). AVOID BRTHG VAPORS. VENTILATE
AREA. CONTAIN & REMOVE W/INERT ABSORB & NON-SPARKING TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DO NOT STORE ABOVE 120F. STORE LG QTYS
ONLY IN BUILDINGS DESIGNED TO COMPLY W/OSHA 1910.106. CLOSE CNTNR
AFTER EACH USE.
Other Precautions:DO NOT TAKE INTERNALLY. OBSERVE GOOD SANITARY
PRACTICES. NOTE:PIGMENTED PAINTS & COATINGS (THOSE WHICH ARE
OPAQUE, COLORED/WHICH HAVE REDUCED GLOSS WHEN DRY) MAY CNTN MATLS
SUCH AS SILICA, TALC, CALCI UM CARBONATE, TITANIUM DIOXIDE,
(SUPDAT)

Respiratory Protection:IF SPRAYED IN AREAS W/UNRESTRICTED VENT, USE
NIOSH/MSHA APPRVD MECH FILTER TO REMOVE OVERSPRAY; IN RESTRICTED
AREAS USE NIOSH/MSHA APPRVD CHEM/MECH FILTER TO REMOVE BOTH
PARTICLES & VAP. FOR ANY METH OF APPLIC IN CONFINED AREAS (ING 8)
Ventilation:PROVIDE SUFFICIENT VENT, IN VOL & PATTERN, TO INSURE VAP
CONC WELL BELOW TLV & LEL LISTED IN INGRED & FIRE & (ING 9)
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKERS GOGG & (ING 10)
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ:SPEC PREC. DURING EMER SITUATIONS OVEREXP TO DECOMP PROD MAY
CAUSE HLTH HAZ. SYMPS MAY NOT BE IMMED APPARENT. OBTAIN MED ATTN.
OTHER PREC:ETC. WHICH ARE HAZ TO INHALE IN DRY POWDER FORM. THE SE
HAZARDS ARE NOT BELIEVED TO BE PRESENT WHEN POWDERS ARE DISPERSED
IN LIQ COATINGS. HOWEVER, PREC IN SPEC PROT (ING 5)

Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:SEE ING
Vapor Density:HVR/AIR
Spec Gravity:0.888
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NOT KNOWN
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:65

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:HIGH TEMPERATURES.
Hazardous Decomposition Products:WHEN HEATED TO DECOMP, AS IN A FIRE/IN
WELDING, MAY PRDCE TOX FUMES SUCH AS CARBON MONOXIDE.

Waste Disposal Methods:DISPOSE I/A/W LOCAL, STATE AND FEDERAL
REGULATIONS. INCINERATE IN APPROVED FACILITY. DO NOT INCINERATE
CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.